40002643.qxd 03/03/2005 19:42 Page 1
Instruction Book
MDC1305AAW
Condenser Tumble Dryer
40002643.qxd 03/03/2005 19:42 Page 3
Introduction
Please read and follow these instructions
carefully and operate the machine accordingly.
This booklet provides important guidelines for
safe use, installation, maintenance and some
useful advice for best results when using your
machine.
Check that no
damage has
occurred to the
machine during
transit. If it has,
call for service by
Maytag.
Keep all documentation in a safe place for future
reference or for any future owners
Delivery information
Please check that the following items are
delivered with the appliance:
Failure to comply
with the above
can compromise
the safety of the
appliance. You
●
Instruction manual
may be charged
for a service call if
a problem with
your machine is
caused by misuse.
Unpacking the product
Remove the machine from its packaging close to
the final location of the machine.
1.
2.
Cut carefully around the base of the
packaging and up one corner.
Remove the polythene sleeve and lift the
dryer off the polystyrene base.
Dispose of the packaging safely. Make
sure it is out of the reach of children,
it is a potential source of danger.
3
40002643.qxd 03/03/2005 19:42 Page 4
Safety reminders
Installation
●
Check that the product has no visible signs of damage before use. If
damaged do not use and please call Maytag Service.
Do not use adapters, or multiple plug connectors.
This machine should not be installed in a bathroom or shower room.
Never install the dryer against curtains and be sure to prevent items from
falling or collecting behind the dryer.
●
●
●
This dryer may be placed on top of a Maytag MAF1200 or 1300 series washing
machine, only when the stacking frame No:30494009 (Available from Maytag
spares) is used."
Use
●
●
WARNING Misuse of a tumble dryer may create a fire hazard.
This machine is solely for domestic use, i.e. to dry household textiles and
garments.
●
This machine should only be used for its intended purpose as described in
this manual. Ensure that the instructions for installation and use are fully
understood before operating the appliance.
●
●
Do not touch the appliance when hands or feet are damp or wet.
Do not lean on the door when loading the machine or use the door to
lift or move the machine.
●
This appliance is not intended for use by young children or infirm
persons unless they have been adequately supervised by a responsible
person to ensure that they can use the appliance safely. Young children
should be supervised to ensure that they do not play with the appliance.
●
●
WARNING Do not use the product if the lint filter is not in position or is
damaged; lint could be ignited.
WARNING Where the hot surface symbol
is located the
temperature rise during operation of the tumble dryer may be in excess
of 60 degrees C.
●
Remove the plug from the electricity supply. Always remove the plug
before cleaning the appliance.
●
●
Do not continue to use this machine if it appears to be faulty.
Lint must not be allowed to collect on the floor around the outside of
the machine.
●
●
The drum inside may be very hot. Always allow the dryer to complete the
cool down period before removing the laundry.
Fabric conditioners or similar products should not be used in the tumble
dryer as they may block the lint filter.
The Laundry
●
WARNING Do not tumble dry, fabrics treated with dry cleaning fluids or
4
40002643.qxd 03/03/2005 19:42 Page 5
industrial chemicals.
●
WARNING Items containing foam rubber (also known as latex rubber) or
similarly textured rubber like materials should not be dried in the tumble
dryer. Such materials can, when heated, produce fire by spontaneous
combustion.
●
●
Plastic articles such as shower caps or babies waterproof napkin covers
should not be placed in the tumble dryer.
Rubber-backed articles, clothes fitted with foam rubber pads, pillows,
galoshes and rubber-coated tennis or training shoes should not be placed
in a tumble dryer.
●
●
●
Under garments that contain metal reinforcement should not be placed
in a tumble dryer.
Always refer to the laundry care labels for directions on suitability for
drying.
Clothes should be spin dried or thoroughly wrung before they are put
into the tumble dryer. Clothes that are dripping wet should NOT be put
into the dryer.
●
●
●
Lighters and matches must not be left in pockets and NEVER use
flammable liquids near the machine.
Glass fibre curtains should NEVER be put in this machine. Skin irritation
may occur if other garments are contaminated with the glass fibres.
Laundry treated or contaminated with vegetable or cooking oil,
petrol/gasoline, dry cleaning solvents, acetone, denatured alcohol, spot
removers, turpentine or similar solvents, wax or wax removers MUST NOT
be put in that machine as they constitute a fire hazard.
Environmental Issues
●
All packaging materials used are environmentally-friendly and recyclable.
Please help dispose of the packaging via environmentally-friendly means.
Your local council will be able to give you details of current means of
disposal.
●
To ensure safety when disposing of an old tumble dryer disconnect the
mains plug from the socket, cut the mains power cable and destroy this
together with the plug. To prevent children shutting themselves in the
machine break the door hinges or the door lock.
Maytag Service
●
To ensure the continued safe and efficient operation of this appliance we
recommend that any servicing or repairs are only carried out by an
authorised Maytag Service agent.
If the appliance is not running properly or breaks down,
switch it off and disconnect the plug from the socket.
Consult Maytag Service for possible repair.
5
40002643.qxd 03/03/2005 19:42 Page 6
Installation
Electrical requirements
If the mains cord
on this appliance
is damaged, it
must be replaced
by a special cord
which is ONLY
obtainable from
the Maytag spares
service. It must be
installed by a
Tumble dryers are supplied to operate at a
voltage of 230V, 50 Hz. Check that the supply
circuit is rated to at least 10A.
Electricity can be extremely dangerous.
This appliance must be earthed.
The socket outlet and the plug on the appliance
must be of the same type.
Do not use multiple plug adapters.
The plug should be accessible for disconnection
after the appliance has been installed.
competent person.
The wires in the mains lead are coloured in
accordance with the following codes:
Blue
NEUTRAL
LIVE
If this appliance is
supplied from a
cord extension set
or electrical
Brown
Green and Yellow
EARTH
portable outlet
device, the cord
set or electrical
portable outlet
device must be
positioned so that
it is not subject to
splashing or
Do not plug the machine in and switch
it on at the mains until the installation is
completed.
For your safety, this dryer must be
correctly installed.
If there is any doubt about installation,
call Maytag Service for advice.
ingress of
moisture.
Adjusting the feet
Once the machine is in place the feet should be
adjusted to ensure that the machine is level.
Adjust the four feet to ensure the machine is firm
and level.
6
40002643.qxd 03/03/2005 19:42 Page 7
Ventilation
Adequate ventilation must be provided in the
room where the tumble dryer is located to
prevent gases from appliances burning other
fuels, including open fires, being drawn into the
room during operation of the tumble dryer.
●
Exhaust air must not be discharged into a
flue which is used for exhausting fumes
from appliances burning gas or other fuels.
●
●
●
Check regularly that the air flowing through
the dryer is not restricted.
Check the lint filter after use, and clean, if
necessary.
The inlet and outlets should be kept free
from obstructions. To ensure adequate
ventilation the space between the bottom
of the machine and the floor must not be
obstructed. There should be a gap of at
least 12mm between the machine and any
obstructions.
●
●
Prevent items from falling or collecting
behind the dryer as these may obstruct the
air inlet and outlet.
NEVER install the dryer up against curtains.
AIR INLET VENTS
AIR OUTLETS
AIR OUTLETS IN THE BASE
7
40002643.qxd 03/03/2005 19:42 Page 8
Preparing the load
Before using the tumble dryer for the first time:
●
●
●
Please read this instruction book thoroughly.
Remove all items packed inside drum.
Wipe the inside of the drum and door with
a damp cloth to remove any dust which may
have settled in transit.
Clothes preparation
Make sure that the laundry you are going to dry
is suitable for drying in a tumble dryer, as shown
by the care symbols on each item.
Do not overload
the drum, large
items when wet
can exceed the
maximum
Check that all fastenings are closed and that
pockets are empty. Turn the articles inside out.
Place clothes loosely in the drum to make sure
that they don't get tangled.
admissible
clothes load
Maximum drying weight
●
Cottons Max. 6.5 kg
(for example:
sleeping bags,
duvets).
●
Synthetics Max. 3.0 kg
8
40002643.qxd 03/03/2005 19:42 Page 9
Sort the load as follows:
●
By care symbols
These can be found on the collar or inside
seam:
Suitable for tumble drying.
Tumble drying at high temperature.
Tumble drying at low temperature only.
Do not tumble dry.
If the item does not have a care label it
must be assumed that it is not suitable
for tumble drying.
●
●
By amount and thickness
Whenever the load is bigger than the dryer
capacity, separate clothes according to
thickness (e.g. towels from thin underwear).
By type of fabric
Cottons/linen: Towels, cotton jersey, bed and
table linen.
Synthetics: Blouses, shirts, overalls, etc.
made of polyester or polyamid, as well as
for cotton/synthetic mixes.
●
By drying level
Sort into: iron dry, cupboard dry, etc. For
delicate articles press the Acrylics Synthetics
button to select low drying temperature.
9
40002643.qxd 03/03/2005 19:42 Page 10
Drying advice
Do not tumble dry:
IMPORTANT: Do
not dry articles
which have been
treated with a
dry cleaning fluid
or rubber clothes
(danger of fire or
explosion).
Woollens, silk, delicate fabrics, nylon stockings,
delicate embroidery, fabrics with metallic
decorations, garments with PVC or leather
trimmings, training shoes, bulky items such as
sleeping bags, etc.
Energy saving
Only put into the tumble dryer laundry which has
been thoroughly wrung or spin-dried. The drier
the laundry the shorter the drying time thus
saving electricity.
During the last
15 minutes the
load is always
tumbled in cool
air.
ALWAYS
●
Try to dry the maximum weight of laundry,
this will save time and electricity.
●
Check that the filter is clean before every
drying cycle.
NEVER
●
Exceed the maximum weight, this will waste
time and electricity.
●
Put dripping wet items into the tumble
dryer, this may damage the appliance.
Drying guide
The table shows approximate drying times,
depending on the type of fabric and dampness of
the clothes.
HEAT
SETTING
HEAVY
LOAD
MEDIUM
LOAD
LIGHT
LOAD
INDICATOR
LIGHT
Fabric
COTTON
SYNTHETICS
ACRYLIC
HIGH
140-175 min 70-80 min
50-65 min
40-55 min
30-40 min
OFF
ON
ON
LOW
–
–
70-80 min
50-65 min
LOW
10
40002643.qxd 03/03/2005 19:42 Page 11
Controls and indicators
FILTER CARE
INDICATOR
COUNTDOWN
DISPLAY
EMPTY
WATER
INDICATOR
ON OFF
BUTTON
PROGRAMME
SELECTOR
ACRYLICS
SYNTHETICS
BUTTON
START RESET
BUTTON
Control panel and indicator lights
Programme Selector – Select the required programme
On Off button and indicator – Press to switch on, the indicator will light
Start Reset – Press to commence the selected drying programme. Press for
5 seconds to cancel/reset the programme
Acrylics Synthetics button – Press to reduce the heat level for delicate items,
the indicator above the button will light up. To change the heat setting the
programme must be reset
Low Heat – Indicator light ON
High Heat – Indicator light OFF
Empty Water indicator – lights when the water container is full
Filter Care indicator – lights when the filter needs cleaning
COUNTDOWN display
START – When the dryer is switched On the START indicator will flash, when
the programme starts the START indicator will light up
60' – Indicator lights when there is less than 60 minutes left until completion
of the programme
15' - Indicator lights when there is less than 15 minutes left until completion
of the programme. At this stage of the drying cycle the machine enters the
Cool Down phase
END - Indicator lights when the programme is finished.
11
40002643.qxd 03/03/2005 19:42 Page 12
Door and Filter
Opening the door
Pull on handle to open the door.
To restart the dryer, close the door and press
Start Reset.
WARNING!
When the tumble dryer is in use the
drum and door may be VERY HOT.
Filter
IMPORTANT: To maintain the efficiency of the
dryer check that the lint filter is clean before
each drying cycle.
1.
2.
3.
Pull the filter upwards.
Open filter as shown.
Gently remove lint using a soft brush or
your fingertips.
4.
Snap the filter together and push back into
place.
Filter Care Indicator
Filter Care lights when the filter needs cleaning.
If the laundry is not drying check that the filter is
not clogged.
12
40002643.qxd 03/03/2005 19:42 Page 13
Water Container
The water removed from the laundry during the
drying cycle is collected in a container at the
bottom of the dryer.
When the container is full the Empty Water
indicator on the control panel will light, and the
container MUST be emptied. However, we
recommend that the container is emptied after
each drying cycle.
NOTE: Very little water will collect during the
first few cycles of a new machine as an internal
reservoir is filled first.
To remove the container
1.
Gently pull the bottom of the kickplate so
that it unclips from the dryer. The top
section can then be unhinged allowing the
kickplate to be completely removed.
2.
Pull firmly on the handgrip and slide the
water container out of the dryer.
Support the container with both hands. When
full, the water container will weigh about 4kg.
3.
4.
Open the lid located on the top of the
container and empty the water.
Refit the lid and slide the water container
back into position. PUSH FIRMLY INTO
PLACE.
5.
Refit the kickplate by engaging the hinges
at the top and 'snapping' the lower clips
into place.
13
40002643.qxd 03/03/2005 19:42 Page 14
Condenser
Important: Always switch off and remove the
plug from the electricity supply before cleaning
the condenser.
To maintain the efficiency of the dryer regularly
check that the condenser is clean.
To remove the
condenser
1.
Remove the kickplate (see page 13).
2.
Turn the two locking levers anti-clockwise
and pull out the condenser.
3.
Pull out the condenser unit.
4.
Gently remove any dust or lint with a cloth,
then wash the unit by holding it under a
running tap turning it so that water flows
between the plates, to remove any dust or
lint.
5.
6.
Refit the condenser ensuring it is in the
correct way (as indicated by the arrow) and
pushed firmly into place. Lock the two levers
by turning them clockwise.
Refit the kickplate.
14
40002643.qxd 03/03/2005 19:42 Page 15
Selecting the Programme
The Sensor Dry machine gives many options for drying the laundry to suit all
circumstances.
The table below lists the programmes and the function of each programme.
Programme
Description
1 - Bone Dry
Select the degree of dryness that you require.
2 - Extra Dry
This ranges from Bone Dry for bath towels and
bathrobes, through Cupboard Dry for items that
will be put away without ironing, to the
programmes that leave the laundry suitable for
ironing.
3 - Cupboard Dry
4 - Iron Dry
5 - Medium Dry
6 - Damp Dry
Wrinkle Prevent
The Wrinkle Prevent programme provides a
conditioning and anticrease function. The dryer will
heat the load for 9 minutes followed by a 3 minute
cool down period and is especially good for
garments which may have been left for some time
prior to ironing, in a linen basket for example.
Garments may also become stiffened when dried
outside on a washing line or inside on radiators.
The Wrinkle Prevent process relaxes the creases in
the fabric making ironing quicker and easier.
75 minutes of drying
60 minutes of drying
45 minutes of drying
30 minutes of drying
Tumbling of laundry in cool air
75'
60'
45'
30'
Refresh
Note: The sensor may not detect a small load of
small articles. For small loads and separate items
or pre-dried fabrics with low moisture content,
use the timed programmes. Set the programme
between 30 and 75 minutes depending on the
load size and dryness required, and select high or
low heat depending upon the fabric type.
If the sensor does not detect the item the dryer
will only operate for 10 minutes before going
into cooldown.
If the load is too large or too wet to tumble dry
the dryer will automatically go into cooldown
after 180 minutes.
15
40002643.qxd 03/03/2005 19:42 Page 16
Operation
1.
Open the door and load the drum with
laundry. Ensure that garments do not hinder
closure of the door.
2.
3.
Gently close the door pushing it slowly until
you hear the door 'click' shut.
Press the On Off button to switch on the
dryer. The indicator will light up and the
START indicator will flash.
4.
5.
Turn the Programme Selector dial to select
the required drying program (see
Programme Guide).
If drying synthetics, acrylics or delicate items,
press the Acrylics Synthetics button to
reduce the heat level. The light above the
push button will light up when the machine
is in low heat setting. To deselect this status
the machine must be reset.
WARNING!
The drum, door
and load may be
6.
Press the Start Reset button. The dryer will
start automatically and the START indicator
will be continuously lit.
very hot.
7.
The COUNTDOWN display will show the
drying progress in terms of time remaining.
8.
If the door is opened during the programme
to check the laundry, it is necessary to press
Start Reset to recommence drying after the
door has been closed.
9.
When the 15' indicator is lit the machine
will enter the cool down phase, the clothes
will be tumbled in cool air allowing the load
to cool down.
10. When the programme is complete the END
indicator will light.
16
40002643.qxd 03/03/2005 19:42 Page 17
Cancelling and resetting
the programme
To cancel a programme press the Start Reset
button for 5 seconds. The machine will indicate
that it has been reset by the START indicator
flashing. It is possible to change the programme
within the first 10 minutes without using the
cancel and reset function.
Cleaning and Routine
Maintenance
Cleaning the dryer
IMPORTANT
●
Clean the filter and empty the water
container after every drying cycle.
Always switch
off and remove
the plug from
the electricity
supply before
cleaning this
appliance.
●
●
Regularly clean the condenser.
After each period of use, wipe the inside of
the drum and leave the door open for a
while to allow circulation of air to dry it.
●
●
●
Wipe the outside of the machine and the
door with a soft cloth.
DO NOT use abrasive pads or cleaning
agents.
To prevent the door sticking or the build up
of lint periodically clean the inner door and
gasket with a damp cloth.
Technical specifications
For electrical data
refer to the
rating label on
the front of the
dryer cabinet
(with the door
open).
Drum capacity
Maximum load
Height
115 litres
6.5 kg
85cm
Width
60cm
Depth
60cm
17
40002643.qxd 03/03/2005 19:42 Page 18
Troubleshooting
What might be the cause of...
Defects you can remedy yourself
Before calling Maytag Service for technical advice please run through the
following checklist. A charge will be made if the machine is found to be
working or has been installed incorrectly or used incorrectly. If the problem
persists after completing the recommended checks, please call Maytag Service,
they may be able to assist you over the telephone.
Drying time is too long/clothes are not dry enough…
●
●
Have you selected the correct drying time/programme?
Were the clothes too wet? Were the clothes thoroughly wrung or spin-
dried?
●
●
●
●
●
Does the filter need cleaning?
Does the condenser need cleaning?
Is the dryer overloaded?
Are the inlets, outlets and base of the dryer free from obstructions?
Has the Acrylics Synthetics option been selected from a previous cycle?
The dryer does not operate…
●
Is there a working electricity supply to the dryer? Check using another
appliance such as a table lamp.
●
●
●
●
●
●
●
●
Is the plug properly connected to the mains supply?
Is there a power failure?
Has the fuse blown?
Is the door fully closed?
Is the dryer switched on, both at the mains supply and at the machine?
Has the drying time or the programme been selected?
Has the machine been switched on again after opening the door?
Has the dryer stopped operating because the water tray is full and needs
emptying?
The dryer is noisy…
●
Switch off the dryer and contact Maytag Service for advice.
The Filter Care Indicator is on…
●
●
Does the filter need cleaning?
Does the condenser need cleaning?
Empty Water Indicator is on…
●
Does the water container need emptying?
18
40002643.qxd 03/03/2005 19:42 Page 19
Maytag Service and Spares
For service and repairs call:.
1300 858 575
MAYTAG (Aust.) Pty. Ltd.
ABN: 88 086 686 884
MAYTAG policy is one of continuous development
and for this reason we reserve the right to
change specifications without prior notice.
19
40002643.qxd 03/03/2005 19:42 Page 20
40002643
|