Date:
MSDS No.:
11/15/06
CAN-M568
Trade Name:
Wearshield BU
Sizes:
All
Supersedes:
3/1/04
M A T E R I A L S A F E T Y D A T A S H E E T
For Welding Consumables and Related Products
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
Section I & II - Preparation and Product Information
Covered Electrode
None
Product Type:
Representative Classifications:
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
Section III - Hazardous Ingredients (1)
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed. All ingredients listed may not be present in all sizes.
(1) The term “hazardous” in “Hazardous Ingredients” should be interpreted as a term required and defined in the Hazardous Products Act and does not
necessarily imply the existence of any hazard.
TLV
LD50
LC50 mg/m3
Ingredients:
CAS No. Wt. % mg/m3 (Route/Species) (Route/Species)
Iron
7439-89-6
1317-65-3
1344-09-8
7789-75-5
7440-21-3
7439-96-5
7440-47-3
14808-60-7
65996-74-9
10-30
5-10
1-5
10*
10
Not Available
Not Available
1153 mg/kg
(oral/rat)
4250 mg/kg
(oral/rat)
Not Available
Not Available
Not Available
Not Available
Limestone and/or calcium carbonate
Silicates and other binders
10*
Fluorides (as F)
1-5
2.5
Silicon and/or silicon alloys and compounds (as Si)
Manganese and/or manganese alloys and compounds (as Mn)
Chromium and chromium alloys or compounds (as Cr)
Quartz
1-5
10*
Not Available
9 g/kg
(oral/rat)
Not Available
2.3 LCLo
(inhalation/human)
1-5
0.2
2.16 mg/kg LDLo
(intravenous/rat)tumorigenic
200 mg/kg LDLo
(intratracheal/rat)
1-5
0.5(b)
#0.05**
5
Not Available
300 LCLo
(inhalation/human)
0.1-1
0.1-1
Iron oxides (as Fe)
Not Available
Not Available
Carbon steel core wire
10*
7439-89-6
60-100
Not Available
Not Available
Notes: (*) Not listed. Nuisance value maximum is 10 milligrams per cubic (LDLo, LCLo) Lowest published toxic concentration.
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(b) The OSHA PEL for chromium (VI) is 5 micrograms
(**)
(#)
As respirable dust.
(0.005 milligrams) per cubic meter. The TLV for water
soluble chromium (VI) is 0.05 milligrams per cubic meter
and the TLV for insoluble chromium (VI) is 0.01
milligrams per cubic meter.
Crystalline silica (quartz) is on the IARC (International Agency for
Research on Cancer) and NTP (National Toxicology Program) lists
as posing a carcinogenic risk to humans.
Section IV - Physical Data
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable to
this product and its use.
Section V - Hazard Data
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in
Section VIII. Product is inert, no special handling or spill procedures required.
Rev 11/06b
(CONTINUED ON SIDE TWO)
|